Petroleum Exploration and Development >

2018 , Vol. 45 >Issue 4: 657 - 668

DOI: https://doi.org/10.11698/PED.2018.04.11

OIL AND GAS FIELD DEVELOPMENT

New progress and prospect of oilfields development technologies in China

  • YUAN Shiyi ,
  • WANG Qiang
Expand
  • 1. CNPC Advisory Center, Beijing 100724, China;
    2. State Key Laboratory of Enhanced Oil Recovery, Beijing 100083, China;
    3. Research Institute of Petroleum Exploration & Development, PetroChina, Beijing 100083, China;

Received date: 2018-03-26

  Revised date: 2018-05-28

  Online published: 2018-06-13

Fold

Abstract

As technologies advance in oilfield development, mature oilfields are able to keep sustainable production and complex oilfields difficult to produce in the past are put into production efficiently. In this work, new progresses of main development technologies for medium-high permeability and high water cut, low permeability, heavy oil, complex faulted block and special lithology reservoirs in the past decade, especially those international achievements made in enhanced oil recovery, were summarized, the key problems and major challenges that different oilfields are facing were analyzed, and the development route and direction of three-generation technologies were proposed as “mature technology in industrialized application, key technology in pilot test and innovative technology for backup”. The key research contents should focus on: (1) Fine water flooding and chemical flooding for mature oilfields, improving oil recovery after chemical flooding, and gas flooding for low permeability reservoirs must be researched and tested in field further. (2) Study on subversive technologies like nanometer smart flooding, in-situ upgrading and injection and production through the same well should be strengthened. (3) EOR technologies for low oil price, new fields (deep sea, deep layer, unconventional reservoirs etc.) and highly difficult conditions (the quaternary recovery after chemical flooding, tertiary recovery in ultra-low permeability reservoirs) should be stocked up in advance. The development cost must be lowered significantly through constant innovation in technology and reservoir management to realize sustainable development of oilfields.

Key words： various oil reservoirs; oilfield development; enhanced oil recovery; main technology; technological development

Cite this article

YUAN Shiyi , WANG Qiang . New progress and prospect of oilfields development technologies in China[J]. Petroleum Exploration and Development, 2018 , 45(4) : 657 -668 . DOI: 10.11698/PED.2018.04.11

References

[1] 金毓荪, 林志芳, 甄鹏, 等. 陆相油藏分层开发理论与实践[M]. 北京: 石油工业出版社, 2016: 10-17.
JIN Yusun, LIN Zhifang, ZHEN Peng, et al.Theory and practice of stratified development in continental reservoir[M]. Beijing: Petroleum Industry Press, 2016: 10-17.
[2] 刘宝和, 胡文瑞, 王乃举, 等. 中国油气田开发志(综合卷)[M]. 北京: 石油工业出版社, 2011: 44-75.
LIU Baohe, HU Wenrui, WANG Naiju, et al.Development of oil and gas fields in China (Comprehensive volume)[M]. Beijing: Petroleum Industry Press, 2011: 44-75.
[3] 贾爱林, 程立华. 数字化精细油藏描述程序方法[J]. 石油勘探与开发, 2010, 37(6): 709-715.
JIA Ailin, CHENG Lihua.The technique of digital detailed reservoir characterization[J]. Petroleum Exploration and Development, 2010, 37(6): 709-715.
[4] 李阳, 吴胜和, 侯加根, 等. 油气藏开发地质研究进展与展望[J]. 石油勘探与开发, 2017, 44(4): 569-579.
LI Yang, WU Shenghe, HOU Jiagen, et al.Progress and prospects of reservoir development geology[J]. Petroleum Exploration and Development, 2017, 44(4): 569-579.
[5] 何江川, 廖广志, 王正茂. 油田开发战略与接替技术[J]. 石油学报, 2012, 33(3): 519-525.
HE Jiangchuan, LIAO Guangzhi, WANG Zhengmao.Oilfield development strategy and replacement techniques[J]. Acta Petrolei Sinica, 2012, 33(3): 519-525.
[6] 高大鹏, 叶继根, 胡云鹏, 等. 基于洛伦兹曲线模型评价精细分层注水效果[J]. 石油勘探与开发, 2015, 42(6): 787-793.
GAO Dapeng, YE Jigen, HU Yunpeng, et al.Application of Lorenz-curve model to stratified water injection evaluation[J]. Petroleum Exploration and Development, 2015, 42(6): 787-793.
[7] 袁士义. 化学驱和微生物驱提高石油采收率的基础研究[M]. 北京: 石油工业出版社, 2010: 1-12.
YUAN Shiyi.Fundamental study on enhanced oil recovery by chemical flooding and microbial flooding[M]. Beijing: Petroleum Industry Press, 2010: 1-12.
[8] WANG D, XIA H, YANG S, et al.The influence of visco-elasticity on micro forces and displacement efficiency in pores, cores and in the field[R]. SPE 127453, 2010.
[9] 程杰成, 吴军政, 胡俊卿. 三元复合驱提高原油采收率关键理论与技术[J]. 石油学报, 2014, 35(2): 310-318.
CHENG Jiecheng, WU Junzheng, HU Junqing.Key theories and technologies for enhanced oil recovery of alkaline/surfactant/ polymer flooding[J]. Acta Petrolei Sinica, 2014, 35(2): 310-318.
[10] 廖广志, 王强, 王红庄, 等. 化学驱开发现状与前景展望[J]. 石油学报, 2017, 38(2): 196-207.
LIAO Guangzhi, WANG Qiang, WANG Hongzhuang, et al.Chemical flooding development status and prospect[J]. Acta Petrolei Sinica, 2017, 38(2): 196-207.
[11] 王其伟. 泡沫驱油发展现状及前景展望[J]. 石油钻采工艺, 2013, 35(2): 94-97.
WANG Qiwei.Present situation and development prospect of foam flooding[J]. Oil Drilling & Production Technology, 2013, 35(2): 94-97.
[12] 何江川, 廖广志, 王正茂. 关于二次开发与三次采油关系的探讨[J]. 西南石油大学学报(自然科学版), 2011, 33(3): 96-100.
HE Jiangchuan, LIAO Guangzhi, WANG Zhengmao.Study on the relationship between secondary development and tertiary recovery technology[J]. Journal of Southwest Petroleum University (Science & Technology Edition), 2011, 33(3): 96-100.
[13] 刘合, 郝忠献, 王连刚, 等. 人工举升技术现状与发展趋势[J]. 石油学报, 2015, 36(11): 1441-1448.
LIU He, HAO Zhongxian, WANG Liangang, et al.Current technical status and development trend of artificial lift[J]. Acta Petrolei Sinica, 2015, 36(11): 1441-1448.
[14] 罗健辉, 丁彬, 燕友果, 等. 烷烃修饰SiO2纳米颗粒油/水界面吸附特性的分子动力学模拟[J]. 中国石油大学学报(自然科学版), 2015, 39(2): 130-136.
LUO Jianhui, DING Bin, YAN Youguo, et al.Molecular dynamics simulation of adsorption behavior of alkyl-modified SiO2 nanoparticles at oil/water interface[J]. Journal of China University of Petroleum (Edition of Natural Science), 2015, 39(2): 130-136.
[15] 胡文瑞. 中国低渗透油气的现状与未来[J]. 中国工程科学, 2009, 11(8): 29-37.
HU Wenrui.The present and future of low permeability oil and gas in China[J]. Engineering Sciences, 2009, 11(8): 29-37.
[16] 袁士义, 宋新民, 冉启全. 裂缝性油藏开发技术[M]. 北京: 石油工业出版社, 2004: 24-31, 275-281.
YUAN Shiyi, SONG Xinmin, RAN Qiquan.Development technology of fractured reservoir[M]. Beijing: Petroleum Industry Press, 2004: 24-31, 275-281.
[17] 王友净, 宋新民, 田昌炳, 等. 动态裂缝是特低渗透油藏注水开发中出现的新的开发地质属性[J]. 石油勘探与开发, 2015, 42(2): 222-228.
WANG Youjing, SONG Xinmin, TIAN Changbing, et al.Dynamic fractures are an emerging new development geological attribute in water-flooding development of ultra-low permeability reservoirs[J]. Petroleum Exploration and Development, 2015, 42(2): 222-228.
[18] 沈平平, 廖新维. 二氧化碳地质埋存与提高石油采收率技术[M]. 北京: 石油工业出版社, 2009: 128-144.
SHEN Pingping, LIAO Xinwei.The technology of carbon dioxide stored in geological media and enhanced oil recovery[M]. Beijing: Petroleum Industry Press, 2009: 128-144.
[19] 袁士义. 二氧化碳减排、储存和资源化利用的基础研究论文集[M]. 北京: 石油工业出版社, 2014: 1-7, 319-332.
YUAN Shiyi.Fundamental research of emission reduction, storage and resource utilization of carbon dioxide[M]. Beijing: Petroleum Industry Press, 2014: 1-7, 319-332.
[20] 刘玉章, 陈兴隆. 低渗油藏CO2驱油混相条件的探讨[J]. 石油勘探与开发, 2010, 37(4): 466-470.
LIU Yuzhang, CHEN Xinglong.Miscible conditions of CO2 flooding technology used in low permeability reservoirs[J]. Petroleum Exploration and Development, 2010, 37(4): 466-470.
[21] 袁士义. 注气提高油田采收率技术文集[M]. 北京: 石油工业出版社, 2016: 1-15.
YUAN Shiyi.Symposium of gas drive to improve oil recovery[M]. Beijing: Petroleum Industry Press, 2016: 1-15.
[22] 杜金虎, 刘合, 马德胜, 等. 试论中国陆相致密油有效开发技术[J]. 石油勘探与开发, 2014, 41(2): 198-205.
DU Jinhu, LIU He, MA Desheng, et al.Discussion on effective development techniques for continental tight oil in China[J]. Petroleum Exploration and Development, 2014, 41(2): 198-205.
[23] 李侠清, 张弛, 张贵才, 等. 黏弹性表面活性剂在油田中的应用[J]. 日用化学工业, 2014, 44(9): 521-524, 538.
LI Xiaqing, ZHANG Chi, ZHANG Guicai, et al.Applications of viscoelastic surfactant in oilfield[J]. China Surfactant Detergent & Cosmetics, 2014, 44(9): 521-524, 538.
[24] 罗健辉, 王平美, 彭宝亮, 等. 低渗透油田水驱扩大波及体积技术探讨[J]. 油田化学, 2017, 34(4): 756-760.
LUO Jianhui, WANG Pingmei, PENG Baoliang, et al.Discussion on expanding swept volume technique of water flooding in low permeability oilfield[J]. Oilfield Chemistry, 2017, 34(4): 756-760.
[25] 张抗. 中国和世界地缘油气[M]. 北京: 地质出版社, 2008: 33-49.
ZHANG Kang.Geographic peripheral oil and gas in China and world[M]. Beijing: Geological Publishing House, 2008: 33-49.
[26] 李兆敏, 鹿腾, 陶磊, 等. 超稠油水平井CO2与降黏剂辅助蒸汽吞吐技术[J]. 石油勘探与开发, 2011, 38(5): 600-605.
LI Zhaomin, LU Teng, TAO Lei, et al.CO2 and viscosity breaker assisted steam huff and puff technology for horizontal wells in a super-heavy oil reservoir[J]. Petroleum Exploration and Development, 2011, 38(5): 600-605.
[27] 曹嫣镔, 刘冬青, 张仲平, 等. 胜利油田超稠油蒸汽驱汽窜控制技术[J]. 石油勘探与开发, 2012, 39(6): 739-743.
CAO Yanbin, LIU Dongqing, ZHANG Zhongping, et al.Steam channeling control in the steam flooding of super heavy oil reservoirs, Shengli Oilfield[J]. Petroleum Exploration and Development, 2012, 39(6): 739-743.
[28] 廖广志, 马德胜, 王正茂, 等. 油田开发重大试验实践与认识[M]. 北京: 石油工业出版社, 2018: 328, 581-600.
LIAO Guangzhi, MA Desheng, WANG Zhengmao, et al.Practice and theory of industrial & pilot test in oilfield development[M]. Beijing: Petroleum Industry Press, 2018: 328, 581-600.
[29] 罗健, 李秀峦, 王红庄, 等. 溶剂辅助蒸汽重力泄油技术研究综述[J]. 石油钻采工艺, 2014, 36(3): 106-110.
LUO Jian, LI Xiuluan, WANG Hongzhuang, et al.Research on ES-SAGD technology[J]. Oil Drilling & Production Technology, 2014, 36(3): 106-110.
[30] 王元基, 何江川, 廖广志, 等. 国内火驱技术发展历程与应用前景[J]. 石油学报, 2012, 33(5): 909-914.
WANG Yuanji, HE Jiangchuan, LIAO Guangzhi, et al.Overview on the development history of combustion drive and its application prospect in China[J]. Acta Petrolei Sinica, 2012, 33(5): 909-914.
[31] 关文龙, 张霞林, 席长丰, 等. 稠油老区直井火驱驱替特征与井网模式选择[J]. 石油学报, 2017, 38(8): 935-946, 972.
GUAN Wenlong, ZHANG Xialin, XI Changfeng, et al.Displacement characteristics and well pattern selection of vertical-well fire flooding in heavy oil reservoirs[J]. Acta Petrolei Sinica, 2017, 38(8): 935-946, 972.
[32] 周明辉, 孙文杰, 李克文. 纳米催化剂辅助超稠油氧化改质实验研究[J]. 中国科学: 技术科学, 2017, 47(2): 197-203.
ZHOU Minghui, SUN Wenjie, LI Kewen.Experimental research of nano catalyst assisted oxidization upgrading of super heavy oil[J]. SCIENTIA SINICA Technologica, 2017, 47(2): 197-203.
[33] 王玉普, 刘义坤, 邓庆军. 中国陆相砂岩油田特高含水期开发现状及对策[J]. 东北石油大学学报, 2014, 38(1): 1-9.
WANG Yupu, LIU Yikun, DENG Qingjun.Current situation and development strategy of the extra high water cut stage of continental facies sandstone oil fields in China[J]. Journal of Northeast Petroleum University, 2014, 38(1): 1-9.
[34] 邹拓, 徐芳. 复杂断块油田开发后期精细地质建模技术对策[J]. 西南石油大学学报(自然科学版), 2015, 37(4): 35-40.
ZOU Tuo, XU Fang.Technical strategy for fine geological modeling in later development stage of complex fault-block oilfield[J]. Journal of Southwest Petroleum University (Science & Technology Edition),2015, 37(4): 35-40.
[35] 徐芳, 张文旗, 李菊红, 等. “地质网格”技术在复杂断块油藏地质建模中的应用[J]. 石油地球物理勘探, 2013, 48(增刊1): 75-81.
XU Fang, ZHANG Wenqi, LI Juhong, et al.Geological grid technology for 3D geology modeling in complex fault-block reservoirs[J]. Oil Geophysical Prospecting, 2013, 48(Supp. 1): 75-81.
[36] 刘新华, 王建龙, 陈晓倩, 等. 利用复杂结构井开发永安油田永3-1断块剩余油[J]. 石油天然气学报, 2013, 35(6): 116-119.
LIU Xinhua, WANG Jianlong, CHEN Xiaoqian, et al.The application of complex structural wells in producing remaining oil in fault block Yong3-1 of Yong’an Oilfield[J]. Journal of Oil and Gas Technology, 2013, 35(6): 116-119.
[37] 计秉玉, 王友启, 聂俊, 等. 中国石化提高采收率技术研究进展与应用[J]. 石油与天然气地质, 2016, 37(4): 572-576.
JI Bingyu, WANG Youqi, NIE Jun, et al.Research progress and application of EOR techniques in SINOPEC[J]. Oil & Gas Geology, 2016, 37(4): 572-576.
[38] 任付平, 郑雅, 裴亚托, 等. 宝力格油田巴19断块微生物-凝胶组合驱技术研究[J]. 长江大学学报(自科版), 2016, 13(1): 21-24.
REN Fuping, ZHENG Ya, PEI Yatuo, et al.Research and application of microbial gel combination flooding in block Ba19 of Baolige Oilfield[J]. Journal of Yangtze University (Natural Science Edition), 2016, 13(1): 21-24.
[39] 李阳, 侯加根, 李永强. 碳酸盐岩缝洞型储集体特征及分类分级地质建模[J]. 石油勘探与开发, 2016, 43(4): 600-606.
LI Yang, HOU Jiagen, LI Yongqiang.Features and hierarchical modeling of carbonate fracture-cavity reservoirs[J]. Petroleum Exploration and Development, 2016, 43(4): 600-606.
Options
Outlines

/

〈 〉

Copyright © Petroleum Exploration and Development
Address:P. O. Box 910, No.20 Xueyuan Road, Haidian District, Beijing 100083, China
Powered by Beijing Magtech Co. Ltd.